CEN09FA126

The pilot's loss of control due to snow/ice contamination on the airplane's lifting surfaces as a result of his decision not to deice the airplane before departure.

The pilot had filed an instrument flight rules flight plan with a planned departure time of 0700 in order to arrive at his intended destination in time for a planned engagement. He and his passenger arrived at the airport approximately 0800 and requested that the airplane be fueled. The airplane was pulled from its heated hangar into heavy snowfall and fueled at 0917. As the airplane sat outside in the heavy snowfall, a measurable amount of wet slushy snow accumulated on the airplane. The Fixed Base Operator manager suggested to the pilot that the airplane be deiced, but he declined. The airplane was then pulled out to the taxiway in an effort to prevent it from becoming stuck in the snow. At 0939, approximately 22 minutes after the airplane was pulled out if its hangar, the pilot departed with a visibility of 3/4 of a mile in snow and with a 4-knot direct tailwind. The pilot then made a right turn and announced that he was heading to his first waypoint. The airplane continued into an ever tightening right turn until it impacted the ground while in an inverted position about one mile north-northwest of the runway. An examination of the airplane’s wreckage revealed no anomalies with either the engine or airframe that would have contributed to the loss of control. The airplane’s Pilot Operating Handbook and Airplane Flight Manual contained the following limitation: "The aircraft must be clear of all deposits of snow, ice and frost adhering to the lifting surfaces immediately prior to takeoff."

HISTORY OF FLIGHT On January 11, 2009, at 0942 mountain standard time (MST), N604WP, a Pilatus PC-12/45 single-engine turbo-prop airplane, was substantially damaged on impact with terrain following a loss of control shortly after takeoff from the Yampa Valley Airport (HDN), Hayden, Colorado. The private pilot and passenger were fatally injured. The airplane was owned and operated by the Rooney Consulting and Aviation LLC., of Bandon, Oregon. Instrument meteorological conditions prevailed and an instrument flight rules (IFR) flight plan was filed for the 14 Code of Federal Regulations Part 91 personal flight. The 633-nautical mile cross-country flight, which was originating at the time of the accident, was destined for the Chino Airport (CNO), Chino, California. According to the General Manager at Galaxy Aviation, a Fixed Base Operator (FBO) located at HDN, the pilot contacted him about 0730 and asked that the airplane be pulled from its heated hangar and fueled. The airport manager suggested to the pilot that they wait to pull the airplane until after he arrived in order to prevent falling snow from accumulating on the airplane. The pilot agreed and called again around 0800 to let the manager know that he and his passenger had arrived. Three line crew members assisted in getting the airplane ready for departure. The line crew members reported that once the airplane was pulled outside, the pilot performed a walk around inspection before he and the passenger boarded the airplane. While the pilot and passenger remained in the airplane, the airplane was fueled about 0917, and then pulled out to the taxiway in an effort to prevent it from becoming stuck in the snow. The line crew also reported "heavy" snowfall from the time the airplane was pulled from the hangar until the airplane departed. In addition, two of the line crew members reported seeing an accumulation of "wet snow" on the airplane's wings. One of the two line crew members described the accumulation on the wings as “probably a good inch of slushy wet snow.” A line crew member also reported that the FBO manager had suggested to the pilot that he taxi to fuel and de-ice because of the accumulating heavy wet snow; however, the pilot declined. The three line crew members described what they observed during the airplane’s takeoff roll. One reported that the airplane did not take too long to takeoff and that it appeared normal. Another said it appeared as if the airplane was not picking up enough speed during takeoff. The third one stated that it was a slow takeoff roll as if the airplane was “heavy.” In addition, the FBO manager estimated the airplane’s takeoff roll to be about 4,000 feet and then observed the airplane make a shallow right bank before flying out of sight. Airport fire department personnel reported the airplane departed from runway 28 at 0939. A fireman, who observed the airplane takeoff, reported that the airplane appeared to level off momentarily about 500-feet above ground level (AGL) before entering a right turn. He then lost site of the airplane due to reduced visibility. Footage taken by an automated airport camera located on top of the airport’s terminal building, showed the airplane for about 5 seconds as it climbed and then appeared to level off or slightly descend, before leaving the camera’s view. When the pilot did not check in with the Denver Air Traffic Control Center after departure, a search was initiated, and the airplane was found adjacent to the airport a short time later. The airplane was fully engulfed in flames. Radar data revealed that the airplane entered a right turn after takeoff. The right turn continued to tighten through approximate 270 degrees, until the airplane impacted the ground approximately 1 mile north-northwest from the approach end of runway 28. The data also revealed the airplane had momentarily leveled off about 200-feet AGL, and reached a maximum altitude of approximately 900-feet AGL during the turn. PERSONNEL INFORMATION The pilot, age 54, held a private pilot certificate with ratings for airplane single-engine land and instrument airplane. His last Federal Aviation Administration (FAA) third-class medical was issued on June 25, 2008, with the limitations that he must have glasses available for near vision, the medical was not valid for any class after June 30, 2009, and the medical was not valid outside the borders of the United States. A copy of the pilot’s logbook revealed that as of the last entry dated March 10, 2008, the pilot had accumulated an estimated 867 flight hours; of which 82 hours were in the accident airplane. Included in that time were 55 flight hours of actual instrument conditions and 57 flight hours of simulated instrument conditions. The pilot had completed his most recent biannual flight review and instrument proficiency check on March 10, 2008. In addition, a training certificate indicated that the pilot had successfully completed recurrent training for the Pilatus PC-12/45 from American Air Safety Accreditations LLC., on March 10, 2008. Per a signed document dated March 12, 2008, the pilot reported a total of 1,720 flight hours of which 559 hours where in turbine aircraft. On the pilot’s last medical application dated June, 25, 2008, the pilot listed a total of 2,000 flight hours with 150 flight hours in the previous 6 months. Flight records for the 9 months preceding the accident were not recovered during the course of the investigation. AIRCRAFT INFORMATION The 2004-model Pilatus Aircraft LTD., PC-12/45, serial number 604, was a pressurized low wing airplane, with a retractable landing gear, and was configured for 8 occupants. The airplane was powered by a single, Pratt & Whitney Canada PT6A-67B turbo-prop engine, rated at 1,200 horsepower, and was driving a four-bladed constant speed Hartzell propeller. According to the airplane’s logbooks, the airframe and engine’s most recent annual inspection was completed on January 2, 2008, with an airframe and engine total time of 558.4 hours. According to a fuel receipt dated January 11, 2009, the airplane was fueled at HDN, about 0917, with 100 gallons of Jet A aviation fuel. METEOROLOGICAL INFORMATION At 0935, the automated weather observing system at Hayden Airport (HDN), reported wind from 100 degrees at 4 knots, visibility of 3/4 of a mile, overcast sky at 1,200 feet, temperature 19 degrees Fahrenheit, dew point 18 degrees Fahrenheit, with an altimeter setting of 30.38 inches of Mercury. The automated weather observation system at HDN did not have a precipitation discriminator; however, airport personnel were reporting “heavy” snowfall as the airplane was pulled from its hangar through the time the airplane departed. According to the General Manager at Galaxy Aviation, the runway conditions at the time of the airplane’s departure were reported as Thin Loose/Packed Snow. AIDS TO NAVIGATION The initial waypoint on the pilot’s filed flight plan was the Hayden VOR/DME (CHE). CHE was located 4.5 miles from the departure end of runway 28 on a heading of 301 degrees. To fly direct to the VOR the pilot would have needed to make a course correction of approximately 20 degree to the right, after takeoff. COMMUNICATIONS According to a transcript of weather service communications, on January 10, 2009, at 2036, the pilot contacted a Prescott Automated Flight Service Station (AFSS) weather briefer, and filed an IFR flight plan for 0700 the next morning. During the conversation the pilot reported that he had planned to leave that morning; however, because of high winds at his destination airport he elected to depart the next morning. The pilot discussed with the briefer that he needed to be at an engagement near his intended destination the next day at 1200 pacific standard time (PST). During the call he brought the subject of the engagement up several time