OPS10IA020

The local controller's issuance of a takeoff clearance to the Boeing 777 without ensuring that approved separation would exist with the Cessna 182. Contributing to the incident were tower procedures that permitted transitioning aircraft to cross the runway 28 departure corridor at low altitude while runways 28L/R were in use.

An operational error occurred when a Boeing 777 and a Cessna 182 transiting the Class B surface area passed within approximately 480 feet laterally and 300 feet vertically of each other. Both airplanes were under control of air traffic control at the time of the incident. Postincident investigation determined that the local controller issued a takeoff clearance to the Boeing 777 without resolving a potential conflict with the Cessna, which was southbound just west of the airport. The controller attempted to establish approved separation between the two airplanes after the Boeing departed, but was unable to do so. The pilot of the Cessna took evasive action to pass behind the Boeing. Review of tower procedures revealed deficiencies that permitted aircraft to cross the runway 28L/R departure corridor while the runways were active, facilitating conflicts of this nature.

On March 27, 2010, at 1112 Pacific daylight time, an operational error occurred at the San Francisco Airport Traffic Control Tower (SFO ATCT) when United Airlines flight 889 (UAL889), a Boeing 777 en route from San Francisco, California to Beijing, China, and N9870E, a Cessna 182 transiting the SFO class B surface area southbound toward Palo Alto, California, passed within approximately 480 feet laterally and 300 feet vertically of each other over San Bruno, California. Both aircraft were under control of SFO ATCT at the time of the incident. The crew of UAL889 filed a near-midair collision report and a Traffic Alert and Collision Avoidance System (TCAS) report following the incident. There was no damage reported to either aircraft, and no injuries to passengers or crew. According to a company report filed by the crew of UAL889, the SFO local controller cleared the flight for takeoff from runway 28L on the MOLEN 3 departure with clearance to climb to 3,000 mean sea level (msl). The flying First Officer reported after the landing gear was retracted at approximately the runway end, and at 1,100 msl, he heard the tower controller report traffic at 1 o'clock. This was followed immediately by the TCAS "TRAFFIC TRAFFIC" warning. According to the TCAS, the target was at 1,400 msl. The pilots visually acquired a light high wing airplane in a hard left turn at their 1 o'clock position. Both crew members reported seeing only the underside of the airplane. Distance to the airplane described as slant range was 200-300 feet. The First Officer's response was to push forward on the yoke to level the airplane. The other airplane disappeared from view through the 3 o'clock position. The First Officer then looked back into the cockpit at which time TCAS annunciated "ADJUST VERTICAL SPEED", followed by a "DESCEND, DESCEND" command. The First Officer stated he complied with a push over to comply. The climb on MOLEN 3 was then continued. History of Flight N9870E was operating from the area of the city of San Francisco southbound along US 101, a freeway that passes just west of SFO. The pilot contacted the SFO local controller at 1809:34, reporting level at 1,600 feet. The controller instructed the pilot to, "...keep highway 101 off your left side," and the pilot acknowledged. The route the pilot was following is a commonly used transition through the SFO class B surface area. UAL889 was a scheduled 14 Code of Federal Regulations part 121 passenger flight operating from San Francisco, California, to Beijing, China. The pilot was instructed to taxi to runway 28L for departure. At 1810:10, the local controller cleared UAL889 into position and hold on the runway. At 1811:47, UAL889 was cleared for takeoff. At 1812:50, the local controller transmitted, "70 echo traffic off the departure end climbing out of 500 heavy triple 7." The pilot of N9870E responded, "70E in sight." The controller then continued, "70E maintain visual separation pass behind that aircraft." The pilot responded, "70E pass behind 'em." At 1813:03, the controller transmitted, "United 889 heavy traffic's uh just ahead and to your right has you in sight Cessna 1,500 they're maintaining visual separation." At 1813:13, the controller continued, "United 889 heavy traffic's no factor contact Norcal departure." The pilot of UAL889 responded, "OK, that set off the TCAS...that was...that...we need to talk." At 1813:47, UAL889 transmitted, "All right, trip...889's going to uh departure," and the controller acknowledged. At 1815:23, the pilot of UAL889 recontacted SFO tower to request a discrete frequency to contact the tower. The controller instructed the pilot to contact the tower on 128.65, and the pilot acknowledged. At 1817:59, the controller-in-charge (CIC) spoke with UAL889 on 128.65, advising the pilot, "...that was a VFR transition, and uh he was ahead and to your right, he had you in sight, he had visual, and he was instructed to pass behind you." The pilot responded, "Well, his uh flight path was definitely gonna be uh converging with ours and uh there was uh less than uh 500 feet separation between the aircraft if you could uh pull the tapes and uh pull any you know uh radar sweeps we'd appreciate it." The CIC replied, "...understand – he did have visual with you. We'll uh we'll do that though, you can uh get that number from your ops if you want to call." The pilot requested the number, and the CIC again stated that they would need to get the number from UAL operations. The pilot acknowledged and the contact concluded. The CIC logged the incident as a quality assurance review item in the Daily Record of Facility Operations. He also advised the front-line manager, who was out of the cab working on documentation of two previous incidents, of the United pilot's complaint. While still in flight, the captain of UAL889 recontacted the tower through UAL operations to discuss the incident further. The captain stated that she was very upset over the incident because of the close proximity of the Cessna, the lack of warning from the tower, and the TCAS alert indicating that the two aircraft were separated by only 200 feet vertically and horizontally. She questioned the tower's procedures and the separation standards applicable to the encounter, and stated that she would be filing paperwork on the incident. SFO ATCT did not initially file an operational error report on the incident. After review by service area and FAA headquarters management, the facility was directed to file an operational error report based on non-compliance with paragraph 7-2-1 of FAA Order 7110.65, and did so on April 5, 2010. Radar Data Radar data for this report was obtained from the ASR-9 sensor located at Oakland, California, about 8 miles northeast of SFO. Two graphics showing an overview of the paths of the two aircraft and a close view of their minimum separation have been entered in the docket. The applicable separation standard between VFR and IFR aircraft in class B airspace is either 1.5 miles laterally or 500 feet vertically. At closest point of approach, the aircraft were separated by about 480 feet laterally and 350 feet vertically, resulting in a minimum slant range distance between UAL889 and N9870E of about 600 feet. Personnel Interviews The local controller was assigned to SFO ATCT in 1999 and was qualified on all control positions in the tower. Asked about any unusual circumstances on the day of the incident, the local controller noted that he had been controller-in-charge earlier in the shift when another controller had an operational error. Reporting of that incident and the associated paperwork required the attention of the front-line manager (supervisor) on duty and resulted in the supervisor being occupied with administrative duties outside the tower cab for almost the whole shift. That effectively reduced available staffing because the controllers then had to fill the CIC position as well as the control positions. Just before the incident, the radar coordinator asked the local controller if she should accept a handoff from Northern California TRACON on Cessna N9870E. As UAL889 was the only runway 28 departure pending, he told her to take the handoff. The Cessna reported over Hunter's Point (north of the airport), and the local controller instructed the pilot to keep highway 101 off of his left side as he proceeded southbound. The ground controller then began verbally coordinating with the radar coordinator regarding an aircraft that would be taxiing around the west end of runways 28L/R "after the guy on the runway." (UAL889) Ground control then amended the request to cross two aircraft instead of one. The local controller looked at the west end taxiway to check on the positions of the crossing aircraft and then cleared UAL889 for takeoff. He then looked back at taxiway Z to make sure that the taxiing aircraft wer